抄録
In order to investigate the influence of coal property and its slurry concentration on the operability of the preheater at the 150 ton/day NEDOL coal liquefaction pilot plant, the pressure drop as well as the temperatures of tube skin and coal slurry was measured along the length of a hairpin-shaped tube (72 mm φ I.D.×94 mm φ O.D., 440 m in length) of the slurry preheater. Different concentration of coal slurry was prepared for three kinds of coal by using their recycle oil. The measurement of pressure drop and temperatures were conducted under the conditions of coal slurry concentration of 40 to approximately 50 wt% and the gas/slurry feed ratio of 0.27 to approximately 0.35 Nm3-gas/kg-slurry. The results showed that the increase in the pressure drop was observed for Ikeshima bituminous coal, probably due to the swelling of coal particle, whereas little increase was for Tanito Harem subbituminous coal and Adaro brown coal. By simplifying the flow in the tube as a two-phase flow of gas and slurry, the effective viscosity and thermal conductivity of the slurry in the preheater were analyzed.
元の言語 | 英語 |
---|---|
ページ(範囲) | 69-83 |
ページ数 | 15 |
ジャーナル | Nihon Enerugi Gakkaishi/Journal of the Japan Institute of Energy |
巻 | 79 |
発行部数 | 1 |
DOI | |
出版物ステータス | 出版済み - 1 1 2000 |
外部発表 | Yes |
Fingerprint
All Science Journal Classification (ASJC) codes
- Energy(all)
これを引用
Effective viscosity and thermal conductivity of slurry in a preheater of the 150 ton/day NEDOL coal liquefaction pilot plant. / Ishibashi, Hiroshi; Masaki; Onozaki; Oi, Shoichi; Nishibayashi, Takahiro; Kobayashi, Masatoshi; Jun-Ichiro, Hayashi; Itoh, Hironori; Chiba, Tadatoshi.
:: Nihon Enerugi Gakkaishi/Journal of the Japan Institute of Energy, 巻 79, 番号 1, 01.01.2000, p. 69-83.研究成果: ジャーナルへの寄稿 › 記事
}
TY - JOUR
T1 - Effective viscosity and thermal conductivity of slurry in a preheater of the 150 ton/day NEDOL coal liquefaction pilot plant
AU - Ishibashi, Hiroshi
AU - Masaki,
AU - Onozaki,
AU - Oi, Shoichi
AU - Nishibayashi, Takahiro
AU - Kobayashi, Masatoshi
AU - Jun-Ichiro, Hayashi
AU - Itoh, Hironori
AU - Chiba, Tadatoshi
PY - 2000/1/1
Y1 - 2000/1/1
N2 - In order to investigate the influence of coal property and its slurry concentration on the operability of the preheater at the 150 ton/day NEDOL coal liquefaction pilot plant, the pressure drop as well as the temperatures of tube skin and coal slurry was measured along the length of a hairpin-shaped tube (72 mm φ I.D.×94 mm φ O.D., 440 m in length) of the slurry preheater. Different concentration of coal slurry was prepared for three kinds of coal by using their recycle oil. The measurement of pressure drop and temperatures were conducted under the conditions of coal slurry concentration of 40 to approximately 50 wt% and the gas/slurry feed ratio of 0.27 to approximately 0.35 Nm3-gas/kg-slurry. The results showed that the increase in the pressure drop was observed for Ikeshima bituminous coal, probably due to the swelling of coal particle, whereas little increase was for Tanito Harem subbituminous coal and Adaro brown coal. By simplifying the flow in the tube as a two-phase flow of gas and slurry, the effective viscosity and thermal conductivity of the slurry in the preheater were analyzed.
AB - In order to investigate the influence of coal property and its slurry concentration on the operability of the preheater at the 150 ton/day NEDOL coal liquefaction pilot plant, the pressure drop as well as the temperatures of tube skin and coal slurry was measured along the length of a hairpin-shaped tube (72 mm φ I.D.×94 mm φ O.D., 440 m in length) of the slurry preheater. Different concentration of coal slurry was prepared for three kinds of coal by using their recycle oil. The measurement of pressure drop and temperatures were conducted under the conditions of coal slurry concentration of 40 to approximately 50 wt% and the gas/slurry feed ratio of 0.27 to approximately 0.35 Nm3-gas/kg-slurry. The results showed that the increase in the pressure drop was observed for Ikeshima bituminous coal, probably due to the swelling of coal particle, whereas little increase was for Tanito Harem subbituminous coal and Adaro brown coal. By simplifying the flow in the tube as a two-phase flow of gas and slurry, the effective viscosity and thermal conductivity of the slurry in the preheater were analyzed.
UR - http://www.scopus.com/inward/record.url?scp=0342758623&partnerID=8YFLogxK
UR - http://www.scopus.com/inward/citedby.url?scp=0342758623&partnerID=8YFLogxK
U2 - 10.3775/jie.79.69
DO - 10.3775/jie.79.69
M3 - Article
AN - SCOPUS:0342758623
VL - 79
SP - 69
EP - 83
JO - Nenryo Kyokai-Shi/Journal of the Fuel Society of Japan
JF - Nenryo Kyokai-Shi/Journal of the Fuel Society of Japan
SN - 0916-8753
IS - 1
ER -